1. Home
  2. Volvo
  3. S60
  4. 2005
  5. Common Problems, Issues, Recalls, and Reliability

2005 Volvo S60 Common Problems, Issues, Recalls, and Reliability

  • 2005 Volvo S60 Transmission Shifting Issues Due to Internal Failure and Software Issues

    The automatic transmission may develop shifting problems and/or the Check Engine Light may illuminate due to internal component failure and/or software issues. It is always best to be sure the transmission control module has the latest software installed when any major transmission repair is performed.

  • 2005 Volvo S60 Exterior Light Bulbs May Burn Out Prematurely

    It is not uncommon for the exterior light bulbs to burn out prematurely. No repair option has been reported other than replacing the failed bulb.

  • 2005 Volvo S60 Hesitation and Idle Issues Due to Failed Mass Airflow Sensor

    Mass airflow senso r (MAF) failures have been reported, causing engine idle problems, as well as acceleration hesitations. The Check Engine Light will normally illuminate when the MAF starts to fail.

  • 2005 Volvo S60 Front Control Arm Bushings May Wear Out

    The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.

  • 2005 Volvo S60 Erratic Shifting or Loss of Transmission Operation

    Several complaints have been reported regarding Volvo S60 transmission shifting issues. Long shift times between gear shifts, hard shifting, hard downshifting and a loss of transmission operation all together to name a few.

    If the issue is minor, a transmission software update may fix this issue. If available, the software should be updated before any repairs are made.

    There are several technical service bulletins (TSB's) available from Volvo that address these shifting issues and they should be consulted by the repair shop during the automatic transmission diagnostic process.

    Regular servicing of the transmission fluid can help with preventing transmission failure, but not in all cases. Follow the suggested fluid replacement interval recommended by Volvo. You will find this in your owners manual, or find it here: http://bit.ly/Volvo_Owners_Manuals

  • 2005 Volvo S60 Worn Sway Bar Links Causing Knocking Over Bumps

    Front and/or rear sway bar end links may wear out prematurely, causing a knocking noise from the front or rear of the vehicle when driving on bumpy roads. Our technicians recommend inspecting the links at each service, they should be replaced if any looseness is found.

2005 Volvo S60 Questions and Answers

Related Questions

  • Volvo S60 Volvo S60 Headlight Wiring

    2005 VOLVO S60, 4 CYL, 2WD, AUTOMATIC, 65 MILES

    related to exterior-light, headlight, wiring

    I have a 2005 S60 which needed to have the headlight wiring (both lights) replaced becasue of defective wiring. Volvo makes a quick kit for this repair so they are aware of the defect. After one yea..

  • Volvo S60 Headlight Won't Work Despite Chaning Bulb

    2005 VOLVO S60, 5 CYL, AWD, AUTOMATIC, 77 MILES

    related to exterior-light, headlight, not-working

    HELP headlight issue Volvo s60 2005 - Replaced bulb still won't work. The light comes on and quickly goes right off. I have checked the fuses and they are fine. I even swapped them. It is occur..

  • Volvo S60 Coil Connector Reading

    2005 VOLVO S60, 5.2L, 5 CYL, 2WD, AUTOMATIC, 2, 222 MILES

    related to ignition, coil

    I have a misfire with cylinder 2. Why I'm getting 11 volts on my coil connector without the engine running but ignition on? @media(max-width: 960px) { .adt { display: none;padding:0; } } ..

  • Volvo S60 Vehicle Malfunctioning

    2005 VOLVO S60, 124, 000 MILES

    related to exterior-light, brake-light

    When Im at a stop light or on the occasion driving down the road my car starts to lag and it tends to shut off. When that happens the service engine light comes on and when you leave it sitting for ..

  • Volvo S60 2005 Volvo S60 Changing Headlight Bulbs

    2005 VOLVO S60

    related to exterior-light, headlight, replace

    Electrical problem 2005 Volvo S60 6 cyl All Wheel Drive Automatic Really having diffivculty changing the low beam bulbs. Should be easy but guess what. I need help. If anyone knows how ..

  • Volvo S60 2005 Volvo S60 Error Message

    2005 VOLVO S60

    related to exterior-light, brake-light

    Electrical problem 2005 Volvo S60 6 cyl Two Wheel Drive Automatic what does "bulb failure light position" mean? I just change the brake lights bulbs and they appear to work fine, but this..

  • Volvo S60 2005 Volvo S60 Oil Life Meter Resetting

    2005 VOLVO S60, 4 CYL, AWD, AUTOMATIC, 45, 000 MILES

    related to warning-lights, oil-life-reset

    I am having trouble resetting the oil life message window? @media(max-width: 960px) { .adt { display: none;padding:0; } } Tuesday, April 28th, 2009 AT 6:34 PM ..

  • Volvo S60 2005 Volvo S60 Replacing S60 Low Beam

    2005 VOLVO S60

    related to exterior-light, headlight, replace

    2005 Volvo S60 Front Wheel Drive Automatic I need to replace the driver side low beam lamp on a 2005 Volvo S60. Is there a quicker method than removing the entire headlight assembly? @med..

2005 Volvo S60 Maintenance and Repair