1. Home
  4. 2002
  5. Common Problems, Issues, Recalls, and Reliability

Common Problems, Issues, Recalls, and Reliability

  • Check Engine Light for Running Rough and Difficulty Starting

    The exhaust recirculation valve ( EGR ) on the 1996-2012 Acura RL may fail, causing:

    • Illumination of the check engine light
    • OBD trouble codes P0401 and P1491
    • Rough idle
    • Reduced fuel economy
    • Engine vibrations
    • Hesitation or stalling
    • Long cranking before engine starts
    • Failure of state or federal smog tests

    The EGR valve has open and closed positions, and opens or closes on command from the computer.

    Exhaust gases constantly pass through the valve when it is open, leaving carbon deposits on the valve. These carbon deposits may lead the the valve sticking in the open or closed position.

    To correct this issue, sometimes it is sufficient to clean the valve, but replacement is recommended in all cases.

    For further information on your vehicle's issue, try out our diagnostics tool here .

  • Sensor Problems May Cause SRS Light To Turn On

    The Airbag (SRS) warning light may illuminate due to one or more failed sensors. Our technicians recommend complete diagnoses of any stored fault codes because these sensors can be very expensive to replace.

  • Reprogram computer to fix shifting problem in automatic transmission

    Some automatic transmissions have a shifting problem that can be corrected by simply reprogramming the computer.

  • Engine Stalls While Driving and WIll not Start

    The 1996-2006 Acura RL may have issues with the fuel pump and fuel injection relays .

    These relays send power to the fuel pump and fuel injectors when the key is turned to the “ON” position. So, when they fail, there is no electrical current to the necessary fuel system components to send fuel into the engine, causing engine stalling or failure to start.

    In this situation, there are many other possibilities, so testing components is vital for time and money savings.

    If the relays test bad, they must be replaced with relays specific for that circuit.

    To help prolong the life of your under-hood electrical components, ensure the lid for the fuse block is closed, and any factory sealing material is correctly installed.

  • Acura extended automatic transmission warranty

    Acura extended the warranty due to numerous issues with the automatic transmission . Problems with the automatic transmission may make the car undrivable and can result in costly repairs.

  • Engine Clicks but Will Not Start

    The starter motor used on the 1996-2006 Acura RL frequently fails on vehicles around 125,000 miles.

    It may help prolong the life of the starter to service the starter to ensure the connections are clean and tight at the 100,000 mile mark.

  • Check Engine Light Due to EVAP System

    The Check Engine Light may illuminate due to an EVAP system fault. Commonly this is caused by the failure of one of the EVAP control valves.

2002 Questions and Answers

Related Questions

  • Acura Rl 2002 Acura RL I Hear A Clicking Noise

    2002 ACURA RL, 6 CYL, 2WD, AUTOMATIC, 125, 000 MILES

    related to general, noises, click

    I have a few questions. 1- I hear a clicking noise, sometimes when I am turning? 2- I just changed the brakes and pads for the entire car and I hear a screeching noise somewhere in the back. 3- I a..

  • Acura Rl 2002 Acura RL Power Steering

    2002 ACURA RL, 3.5L, 6 CYL, 2WD, AUTOMATIC, 180, 000 MILES

    related to steering, rack-and-pinion

    Replaced the power steering pump, replaced the rack and pinon and still don't have power steering. After starting thr car, everything seemed to be working properly at first. But after turing the s..

  • Acura Rl How Do I Replace The Front And Rear Struts

    2002 ACURA RL

    related to suspension, strut, replace-remove

    I just had a local repair shop replace the starter on my 2002 Acura RL (bad mistake) after 4 weeks I got my car back, the VSA and ABS lights would no go off and the car had no brake lights (paid Ac..

  • Acura Rl 2002 Acura RL

    2002 ACURA RL, 4 CYL, 4WD, AUTOMATIC, 75, 000 MILES

    related to general, noises, rattle

    I hear a rattle coming from the front driver side tire area whenever I hit a bump. It seems to be getting worst I tried looking in the manual but no such luck. Please help me with your expert ..

  • Acura Rl 2002 Acura RL Turn Off Light

    2002 ACURA RL

    related to exterior-light, turn-signal

    2002 Acura RL 6 cyl Front Wheel Drive Automatic turn off maintenance request ligt @media(max-width: 960px) { .adt { display: none;padding:0; } } Friday, April 18th, 2008 AT 8:14 ..

2002 Maintenance and Repair