2003 Volvo S60 Common Problems, Issues, Recalls, and Reliability

• 2003 Volvo S60 Transmission Shifting Issues Due to Internal Failure and Software Issues

  The automatic transmission may develop shifting problems and/or the Check Engine Light may illuminate due to internal component failure and/or software issues. It is always best to be sure the transmission control module has the latest software installed when any major transmission repair is performed.

• 2003 Volvo S60 Exterior Light Bulbs May Burn Out Prematurely

  It is not uncommon for the exterior light bulbs to burn out prematurely. No repair option has been reported other than replacing the failed bulb.

• 2003 Volvo S60 Hesitation and Idle Issues Due to Failed Mass Airflow Sensor

  Mass airflow senso r (MAF) failures have been reported, causing engine idle problems, as well as acceleration hesitations. The Check Engine Light will normally illuminate when the MAF starts to fail.

• 2003 Volvo S60 Front Control Arm Bushings May Wear Out

  The front control arm bushings wear out, resulting in alignment issues and squeaking and/or knocking noises from the front end. Worn bushings will require replacement.

• 2003 Volvo S60 Erratic Shifting or Loss of Transmission Operation

  Several complaints have been reported regarding Volvo S60 transmission shifting issues. Long shift times between gear shifts, hard shifting, hard downshifting and a loss of transmission operation all together to name a few.

  If the issue is minor, a transmission software update may fix this issue. If available, the software should be updated before any repairs are made.

  There are several technical service bulletins (TSB's) available from Volvo that address these shifting issues and they should be consulted by the repair shop during the automatic transmission diagnostic process.

  Regular servicing of the transmission fluid can help with preventing transmission failure, but not in all cases. Follow the suggested fluid replacement interval recommended by Volvo. You will find this in your owners manual, or find it here: http://bit.ly/Volvo_Owners_Manuals

• 2003 Volvo S60 Worn Sway Bar Links Causing Knocking Over Bumps

  Front and/or rear sway bar end links may wear out prematurely, causing a knocking noise from the front or rear of the vehicle when driving on bumpy roads. Our technicians recommend inspecting the links at each service, they should be replaced if any looseness is found.

2003 Volvo S60 Questions and Answers

Related Questions

• Volvo S60 2003 Volvo S60 2.4t Shudders When Accelerating....

  2003 VOLVO S60, 65, 000 MILES

  related to tires, balance

  2003 Volvo S60 2.4t shudders when accelerating. Smooth when coasting. Started before new tires. Continued now that I have new tires. Just rotated and balanced tires and shudder continues. It doe..

  ---

• Volvo S60 The Car 2003 Volvo Runs But There Is A Knocking Noise...

  2003 VOLVO S60, 127, 750 MILES

  related to general, noises, knock

  Car was well taken care of engines starts and runs but knocking noise is heard coming from the engine it sounds like. @media(max-width: 960px) { .adt { display: none;padding:0; } } Tue..

  ---

• Volvo S60 Gas Shutboffoo

  2003 VOLVO S60, 5 CYL, FWD, MANUAL, 112, 000 MILES

  related to safety, inertia-switch, location-

  My 2003 S60 just backed into a wall @a very low speed. Not much damage & no one hurt, but we can not get the car started. If there is an automatic valve that shuts off the gas flow, I woul..

  ---

• Volvo S60 How Do I Get The Front Fog Lights To Operate Without...

  2003 VOLVO S60, 47, 700 MILES

  related to exterior-light, fog-light

  Have a 2003 Volvo S60. Relocating it to Portugal. Need to uncouple the front fog lights from the regular headlights. The fog lights need to operate independently from the headlights, currently t..

  ---

• Volvo S60 Need Advice

  2003 VOLVO S60, 4 CYL, FWD, AUTOMATIC, 141, 000 MILES

  related to suspension, strut, mount, estimate

  I have a 2003 volvo that needs strut assembly, strut brace mount, strut mount w/bearing, control arm w/o b-jnt, w/bushings, timing belt kit, water pump w/bolts, camshaft seal, rt engine moun..

  ---

• Volvo S60 SUSPENSION

  2003 VOLVO S60, 5 CYL, AWD, AUTOMATIC, 250 MILES

  related to suspension

  Car has a new alignment, but pulls to the side when brakeing @media(max-width: 960px) { .adt { display: none;padding:0; } } Tuesday, December 21st, 2010 AT 11:19 PM ..

  ---

• Volvo S60 Is There A Way To "disable Daytime Running Lights"?

  2003 VOLVO S60, 48, 000 MILES

  related to exterior-light, daytime-running-light

  Is there a way to "Disable Daytime Running Lights"? @media(max-width: 960px) { .adt { display: none;padding:0; } } Thursday, October 25th, 2012 AT 5:30 PM ..

  ---

• Volvo S60 Radiator Hose Came Off (several Times)

  2003 VOLVO S60, 130, 000 MILES

  related to engine-cooling, radiator, radiator-hose

  If Volvo V60 gets overheated because radiator hose came off (several times) Is the problem a bad gasket connecting hose to radiator or could there be a problem with the engine blowing the hose off? ..

  ---

• Volvo S60 Runs Great Just Out Of No Where The Dash Went Blank

  2003 VOLVO S60, 145, 000 MILES

  related to interior, dashboard

  I have a 2003 volvo s60 and yesterday the digital display and the analog spedometer went out on way 2work it came back on after I started it back up with lines in the display. To day it did the same..

  ---

• Volvo S60 Coolant Thermostat And Ambient Air Temperature Sensor...

  2003 VOLVO S60, 4 CYL, 2WD, AUTOMATIC, 66, 000 MILES

  related to body, ambient-temperature-sensor

  I'm a single mom needs advice. Took to AutoZone and it said I need to replace coolant thermostat and ambient air temperature sensor. Is this something I need to replace right away. Is it somethin..

  ---

• Volvo S60 Right Front Squeak Sound Like A Bushing Or Strut Loose

  2003 VOLVO S60, 2.5L, 5 CYL, TURBO, AWD, AUTOMATIC, 170 MILES

  related to general, noises, squeak

  Volvo S60, 2003 2.5 l AWD TURBO WITH 170,000 miles. Squeaking / rubbing sound diminishes when the car is driven 15 miles or so. Sound then becomes a slight muffled knock when going over rough road..

  ---

• Volvo S60 Turn Signal Conversion From Incandescent To Led

  2003 VOLVO S60, 95, 000 MILES

  related to exterior-light, turn-signal, wiring

  Hi, I am converting my front left turn signal from incandescent bulbs to led using a resistor. The three wires on the wiring harness are a brown with a stripe, and a white wire and green wire. The..

  ---

• Volvo S60 2003 Volvo S60 Impact Sensor Location

  2003 VOLVO S60

  related to safety, airbag, sensor, location

  Electrical problem 2003 Volvo S60 Automatic Hello, Im from Brazil. I have a crashed volvo s60 and want know where the location of the impact sensor (or switch) the sensor that make the a..

  ---

2003 Volvo S60 Maintenance and Repair

• Causes of 2003 Volvo S60 Engine Vibration
• How To Use a 2003 Volvo S60 Battery Charger
• 2003 Volvo S60 Exhaust Smell Understanding Where The Problem Lies
• How To Tell If You Have a 2003 Volvo S60 Faulty Hydraulic Lifter
• How To Repair a 2003 Volvo S60 Tire Valve
• How To Use a Trickle Charger on your 2003 Volvo S60
• 2003 Volvo S60 Exhaust Manifold Leak Repair Cost: Average Prices To Expect
• Average 2003 Volvo S60 Brake Repair Cost for Each Brake Problem
• Tips for Recharging your 2003 Volvo S60 Battery
• Most Common Signs That Your 2003 Volvo S60 Needs a Transmission Flush
• Burning Smell from 2003 Volvo S60 - Understand What is Happening
• Causes of 2003 Volvo S60 Engine Knock
• The Best 2003 Volvo S60 Battery Brand To Use for Lasting Performance
• 2003 Volvo S60 Tire Companies To Avoid
• 2003 Volvo S60 Tire Alignment: How To Know When You Need It
• How To Tell If You Have a 2003 Volvo S60 Faulty Engine Speed Sensor
• How To Tell If You Have a 2003 Volvo S60 Faulty Head Gasket
• How To Repair 2003 Volvo S60 Hail Damage
• How To Tell If You Have a 2003 Volvo S60 Faulty Coil Pack
• How To Tell If You Have a 2003 Volvo S60 Faulty Alternator
• Most Common 2003 Volvo S60 Transmission Problems
• Using Nitrogen for 2003 Volvo S60 Tire Inflation: Advantages Disadvantages
• How To Tell If You Have a 2003 Volvo S60 Faulty Distributor
• Symptoms of Fried 2003 Volvo S60 Piston Rings
• How To Tell If You Have a 2003 Volvo S60 Faulty Coolant Temperature Sensor
• Advantages and Disadvantages of 2003 Volvo S60 Radial Tires
• How To Reset The 2003 Volvo S60 Tire Pressure Sensor Correctly
• How To Tell If You Have a 2003 Volvo S60 Faulty Ecu
• Common 2003 Volvo S60 Oil Pump Failure Symptoms
• My 2003 Volvo S60 Smells: 7 Tips for Getting Rid of Bad Auto Odors
• 2003 Volvo S60 Acrylic Car Paint: Understanding The Pros and Cons
• Understand 2003 Volvo S60 Brake Noise for a Proper Diagnosis
• How To Tell If You Have a 2003 Volvo S60 Faulty Mass Airflow Sensor
• 2003 Volvo S60 Waxing Temperature - Understanding The Best Time To Wax Your Car
• How To Tell If Its Time for a 2003 Volvo S60 Engine Rebuild
• How To Tell If You Have a 2003 Volvo S60 Faulty Throttle Position Sensor
• Signs Your 2003 Volvo S60 has a Faulty Transmission Filter
• 2003 Volvo S60 Windshield Repair Quote: Average Prices On Common Repairs
• How To Tell When a 2003 Volvo S60 Brake Rotors Need To Be Replaced
• What Happens If Your 2003 Volvo S60 Runs Out of Engine Oil
• How To Repair a 2003 Volvo S60 Aluminum Radiator
• 2003 Volvo S60 Chrome Rim Repair: a How To Guide
• Average 2003 Volvo S60 Tire Puncture Repair Cost
• The Best Way To Polish 2003 Volvo S60 Paint: Two Methods To Consider
• Causes of 2003 Volvo S60 White Exhaust Smoke
• What Should a Full 2003 Volvo S60 Detailing Service Include
• What Does It Mean If You Have a 2003 Volvo S60 Low Oil Pressure At Idle
• 2003 Volvo S60 Wax Formula - Understanding What Its Made Of
• 2003 Volvo S60 Polish and Wax: Are They The Same Which Comes First
• Understanding When You Should Wax Your 2003 Volvo S60 : Hot or Cold Temperature
• 2003 Volvo S60 Paint Types Pros and Cons of Each
• How To Mix 2003 Volvo S60 Paint Properly So The Color Spreads Evenly
• 2003 Volvo S60 Clear Coat Car Paint - Understanding The Pros and Cons
• How To Apply 2003 Volvo S60 Paint Primer Correctly
• 2003 Volvo S60 Spray Painting Techniques for a Proper Coat
• 2003 Volvo S60 Windshield Scratch Repair: a How To Guide
• A Routine 2003 Volvo S60 Maintenance Schedule Based On Engine Mileage
• 2003 Volvo S60 Buyers Guide: Oil Free or Oil Air Compressor
• What To Do If You Start To Get 2003 Volvo S60 Brake Smell
• Causes of 2003 Volvo S60 Blue Exhaust Smoke
• When Should You Turn your 2003 Volvo S60 Brake Rotors
• How To Repair a 2003 Volvo S60 Leaking Gas Tank
• How To Tell If You Have a 2003 Volvo S60 Faulty Manifold Pressure Sensor
• How To Tell If You Have a 2003 Volvo S60 Faulty Oxygen Sensor
• What Happens If Your 2003 Volvo S60 Runs Out of Coolant
• How Often Should You Replace Your 2003 Volvo S60 Radiator Fluid
• 2003 Volvo S60 Radiator Fluid: What To Use What To Avoid
• 2003 Volvo S60 Repair: How To Use Radiator Sealant
• 2003 Volvo S60 Radiator Repair: 3 Soldering Tips for Proper Restoration
• Average 2003 Volvo S60 Radiator Repair Costs: Dont Get Scammed
• Signs of a Worn Out 2003 Volvo S60 Engine Bearing
• Causes of 2003 Volvo S60 Lifter Tick
• How To Bleed a 2003 Volvo S60 Radiator: An Auto Diy Maintenance Guide
• 2003 Volvo S60 Tire Repair: Tire Patch Vs Plug
• Types of 2003 Volvo S60 Brake Pads To Be Aware of
• Pros and Cons of a 2003 Volvo S60 High Flow Air Filter
• Benefits of Changing Your 2003 Volvo S60 Air Filter
• Common Problems Associated With 2003 Volvo S60 Fully Synthetic Oil
• What Is The Difference Between a 2003 Volvo S60 Synthetic Oil and Conventional Oil
• How Often Should You Clean and Condition 2003 Volvo S60 Leather Seats
• How 2003 Volvo S60 Oil Change Affects Gas Mileage
• Advantages That New Tires Give Your 2003 Volvo S60
• How To Prevent a 2003 Volvo S60 Spark Plug Blow Out Ignition: Problems Solved
• Copper Spark Plugs Vs Iridium and Platinum: Understand for Top 2003 Volvo S60 Performance
• How To Fix a 2003 Volvo S60 Power Steering Hose Leak
• Essential 2003 Volvo S60 Power Steering Parts and What They Do
• How To Get Rid of a 2003 Volvo S60 Mildew Smell
• 2003 Volvo S60 Battery or Alternator How To Tell Where The Problem Lies
• Everything You Need To Know About 2003 Volvo S60 Brake Fluid
• Weird 2003 Volvo S60 Air Conditioner Smell: What It Means and How To Fix It